Product ID:ACCELERATOR 4 (RD2132-17)
MSDS Date:01/06/1997
FSC:8040
NIIN:01-181-2355
Status Code:A
MSDS Number: CKHXH

LORD CORP

2000 WEST GRANDVIEW BLVD
ERIE, PA 16514
US

Emergency Phone: 814-763-2345

Info Phone: 814-868-3611

Cage: 30676

LORD CORPORATION, CHEMICAL PRODUCTS DIVISION

ERIE, PA 16514-0038 US

Telephone: 814-868-3611

Cage: 30676

BENZOYL PEROXIDE

CAS: 94-36-0

Fraction By Weight: 10%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3

METHYL ISOBUTYL KETONE

CAS: 108-10-1

Fraction By Weight: 10%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL METHACRYLATE

CAS: 80-62-6

RTECS: OZ5075000

Fraction By Weight: 2%

OSHA PEL 410 MG/M3;100 PPM

ACGIH TLV: 410 MG/M3;100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYLENE CHLORIDE

CAS: 75-09-2

Fraction By Weight: 70%

OSHA PEL 1000 PPM

ACGIH TLV: 50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

TRICHLOROETHYLENE

CAS: 79-01-6

RTECS: KX4550000

Fraction By Weight: 15%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:MAY CAUSE SKIN AND EYE IRRITATION.
MAY CAUSE ALLERGIC SKIN REACTION. MAY CAUSE RESPIRATORY TRACT
IRRITATION.
Effects of Overexposure:EYE CONTACT: MAY CAUSE EYE IRRITATION . MAY
CAUSE SKIN SENSITIZATION. MAY CAUSE DERMATITIS. EFFECTS OF
OVEREXPOSURE INHALATION: MAY CAUSE RESPIRATORY TRACT IRRITATION.
EFFECTS OF OVEREXPOSURE IN GESTION: HARMFUL IF SWALLOWED.
INGESTION IS NOT AN EXPOOTED ROUTE OF ENTRY IN INDUSTRIAL OR
COMMERCIAL USES. CHRONIC SKIN CONTACT MAY CAUSE DERMATITIS.

First Aid:EYE CONTACT: FLUSH EYES IMMEDIATELY WITH LARGE AMOUNTS OF
WATER FOR AT LEAST 15 MINUTES HOLDING EYELIDS OPEN WHILE FLUSHING.
GET PROMPT MEDICAL ATTENTION. SKIN CONTACT: FLUSH CONTAMINATED
SKIN WIT H LARGE AMOUNTS OF WATER WHILE REMOVING CONTAMINATED
CLOTHING. WASH AFFECTED SKIN AREAS WITH SOAP AND WATER. GET
MEDICAL ATTENTION IF SYMPTOMS OCCUR. INHALATION: MOVE PERSON TO
FRESH AIR. RESTOR E AND SUPPORT CONTINUED BREATHING. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET IMMEDIATE MEDICAL
ATTENTION. *

Flash Point Method:SCC
Flash Point:>93.3C, 200.F
93C
Lower Limits:1.4
Upper Limits:44.8
Extinguishing Media:CO2 DRY CHEMICAL FOAM WATER FOG
Fire Fighting Procedures:WEAR FULL FIREFIGHTING PROTECTIVE CLOTHING,
INCLUDING SELF-COMTAINED BREATHING APPARATUS (SCBA). IF WATER IS
USED, FOG NOZZLES ARE PREFERABLE. DURING A FIRE, IRRITATING AND/OR
TOXIC GASES AND PARTIC ULATE MAY BE GENERATED BY THORMAL
DECOMPOSITION OR COMBUSTION.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS LIGHTLY CLOSED. CLOSED
CONTAINERS MAY RUPTURE WHEN EXPOSED TO EXTREME HEAT. USE WATER
SPRAY TO KEEP FIRE EXPOSED CONTAINERS COOL.

Spill Release Procedures:AVOID BREATHING VAPORS. NOTIFY APPROPRIATE
AUTHORITIES IF NECESSARY. AVOID CONTACT. USE APPROPRIATE
RESPIRATORY PROTECTION FOR LARGE SPILLS OR SPILLS IN CONFINED AREA.
KEEP NON-ESSENTIAL PERSONNEL AWAY FROM SPILL AREA. SCOOP SPILLED
MATERIAL INTO AN APPROPRIATE CONTAINER FOR PROPER DISPOSAL. ( IF
NECESSARY, USE INERT ABSORBENT MATERIAL TO AID IN CONTAINING THE
SPILL).

Handling and Storage Precautions:KEEP CLOSURE TIGHT AND CONTAINER
UPRIGHT TO PREVENT LEAKAGE. AVOID SKIN AND EYE CONTACT. WASH
THOROUGHLY AFTER HANDLING. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. E MPTY CONTAINERS
SHOULD NOT BE RE-USED. USE WITH ADEQUATE VENTILATION. **
Other Precautions:*IF SWALLOWED, DO NOT INDUCE VOMITING. GIVE VICTIM
ONE OR TWO GLASSES OF WATER OR MILK. CALL A PHYSICIAN OR POISON
CONTROL CENTER IMMEDIATELY FOR FUTHER INSTRUCTIONS. NEVER GIVE
ANYTHING BY MOUTH T O AN UNCONSCIOUS PERSON. **STORE ONLY IN
WELL-VENTILATED AREAS. KEEP CONTAINER CLOSED WHEN NOT IN USE.

Respiratory Protection:USE A NIOSH/MEHA APPROVED AIR-PURIFYING ORGANIC
VAPOR RESPIRATOR IF OCCUPATIONAL LIMITS ARE EXCEEDED. FOR
EMERGENCY SITUATIONS, CONFINED SPACE USE, OR OTHER CONDITIONS WHERE
EXPOSURE LIMITS MAY BE GR EATLY EXCEEDED, USE AN APPROVED
AIR-SUPPLIED RESPIRATOR. OBSERVE OSHA REGULATIONS (29CFR 1910.13)
FOR RESPIRATOR USE.
Ventilation:SUFFICIENT VENTILATION IN PATTERN AND VOLUME SHOULD BE
PROVIDED IN ORDER TO MAINTAIN AIR CONTAMINANT LEVELS BELOW
RECOMMENDED EXPOSURE LIMITS.
Protective Gloves:USE NEOPRENE, NITRILE, OR RUBBER GLOVES TO PREVENT
SKIN CONTACT.
Eye Protection:SAFETY GOGGLES AND SPLASH GUARDS
Other Protective Equipment:USE DISPOSABLE OR IMPERVIOUS CLOTHING IF
WORK CLOTHING CONTAMINATION IS LIKELY. REMOVE AND WASH
CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
TOILET FACILITY. FOOD OR BEVERAGES SHOULD NOT BE CONSUMED ANYWHERE
THIS PRODUCT IS HANDLED OR STORED. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health

Boiling Pt:>40.C, 104.F
B.P. Text:104-241F
Vapor Density:HEAVIER TH
Spec Gravity:1.25
VOC Pounds/Gallon:781
Evaporation Rate & Reference:SLOWER THAN
Solubility in Water:INSOLUBLE
Appearance and Odor:MILKY LIQUID/SOLVENT ODOR.
Percent Volatiles by Volume:88.9

Stability Indicator/Materials to Avoid:YES
ALUMINUM, ZINC, CAUSTICS, HALOGENS. STRON OXIDIZERS ACIDS, BASES.
Stability Condition to Avoid:ALUMINUM OR GALVANIZED PARTS IN A CLOSED
SYSTEM. DRIED MATERIAL IS FLAMMABLE, SENSITIVE TO SHOCK AND HEAT.
DIRECT SUNLIGHT, SHOCK, AND TEMPERATURES IN EXCESS OF 90'F
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
ALDEHYDES.

Waste Disposal Methods:DISPOSAL SHOULD BE DONE IN ACCORDANCE WITH
FEDERAL (40CFR PART 261), STATE AND LOCAL ENVIROMENTAL CONTROL
REGULATIONS. IF WASTE IS DETERMINED TO BE HAZARDOUS, USE LICENSED
HAZARDOUS WASTE TRANSPORTOR AND DISPOSAL FACILITY.

Toxicological Information:NO PRODUCT TOXICOLOGICAL INFORMATION IS
AVAILABLE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:DOT PROPER SHIPPING NAME: NOT REGULATED DOT
HAZARD CLASS: NONE DOT UN/NA NUMBER: NONE EMERGENCY RESPONSE
RESPONSE GUIDE NUMBER: NONE PACKING GROUP: NONE

SARA Title III Information:OSHA: HAZARDOUS BY DEFINITION OF HAZARD
COMMUNICATION STANDARD (29 CFR 1910.12) THIS PRODUCT CONTAINS
THE FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING REQUIREMENTS OF
SECTION 313 OF TITLE III OF T HE SUPERFUND AMENDMENTS AND
REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372: 1) METHYLENE
CHLORIDE 2) TRICHLOROETHYLENE 3) METHYL ISOBUTYL KETONE 4)
BENZOYL PEROXIDE 5) METHYL METHACRYLATE INV ENTORY STATUS: THE
CHEMICAL SUBSTANCES IN THIS PRODUCT ARE ON THE TSCA SECTION8
INVENTORY.
State Regulatory Information:U.S. FEDERAL REGULATIONS: AS FOLLOWS -
OSHA: HAZARDOUS BY DEFINITION OF HAZARD COMMUNICATION STANDARD (29
CFR 1910.1200) INTERNATIONAL REGULATIONS: AS FOLLOWS - CANADIAN
WHMIS: THIS MSDS HAS BEEN PREPARED IN COMPLIANCE WITH CONTROLLED
PRODUCT REGULATIONS EXCEPT FOR USE OF THE 16 HEADINGS. CANADIAN
WHMIS CLASS: NO INFORMATION AVAILABLE.